• Leave this manual with party responsible for use and operation. • Read, understand and follow these instructions for safe installation and operation. DO NOTDISCARD Tested and Listed by Beaverton Oregon USA OMNI-Test Laboratories, Inc. C US OWNER’S MANUAL Installation and Operation Model: 830-0381 3100-I ACT WOOD INSERT Advanced Combustion Technology (ACT) DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible f

The permanent metal warning plate provided must be attached to the back of the fireplace stating the fire place may have been altered to accommodate the insert and must be returned to original condition for use as a conventional fireplace. September 1, 2008 250-7201E Page 5 RR 4100-I ACT WOOD INSERT LISTINGS These installation instructions describe the installation and operation of the Quadra-Fire 4100-I Wood Insert. This insert meets the U.S. Environmental Protection Agency’s 1990 particulate e

The blower cord can also be installed on the left side. Disconnect the cord from right side. ROUTE WIRES IN FRONT OF FAN. Re-install on the left side. Do not route cord behind the cooling fan. Figure 15B - Right Side Location FAN (BLOWER) REPLACEMENT Included in Kit: Replacement Blower Tools Needed: 5-32 Wrench and Phillips Head Screwdriver. 1. Remove bolts from both sides of the insert and slide the lower cast cover towards you. See Figure 15D 2. Loosen 4 screws (2 on each side of the motor) th

6000GLX shown with Cornerstone surround, Cultured Stone's Chardonnay Limestone and Chateau Deluxe front in new bronze fi nish C. 6000GL shown with Hearst cast mantel, cast stone hearth and insert panels, and Halston front in graphite fi nish The best brightest & C It’s the one that started a revolution. In 1987, the 6000 Series introduced direct vent technology, making it the most sought after gas fi replace on the market.Today, the 6000 Series still combines beautiful design with the latest inn

• Inspect gasket seal and its condition. • Inspect fixed glass assembly for scratches and nicks that can lead to breakage when exposed to heat. • Confirm there is no damage to glass or glass frame. Replace as necessary. • Verify that fixed glass assembly is properly retained and attachment components are intact and not damaged. Replace as necessary. Logs Frequency: Annually By: Qualifi ed Service Technician Tools needed: Protective gloves. • Inspect for damaged or missing logs. Replace as necess

NOTICE: Treatment of ceiling firestops and wall shield firestops and construction of the chase may vary with the type of building. These instructions are not substitutes for the requirements of local building codes. Therefore, you MUST check local building codes to determine the requirements to these steps. Chases should be constructed in the manner of all outside walls of the home to prevent cold air drafting problems. The chase should not break the outside building envelope in any manner. Wall

- Use low resistance thermostat wire for wiring from ignition system to the wall switch and thermostat. - Keep wire lengths short as possible. A. Wiring Requirements NOTICE: This appliance must be electrically wired and grounded in accordance with local codes or, in the absence of local codes, with National Electric Code ANSI/NFPA 70-latest edition or the Canadian Electric Code CSA C22.1. • Wire the appliance junction box to 110-120 VAC. This is required for use of optional accessories (standing

In a standing pilot system the pilot will always stay on. Heat & Glo • 6000G, 6000G-IPI • 2103-900 Rev. O • 12/08 3 33 Maintenance and Service Any safety screen or guard removed for servicing must be replaced prior to operating the fireplace. When properly maintained, your fireplace will give you many years of trouble-free service. We recommend annual service by a qualified service technician. A. Maintenance Tasks-Homeowner Installation and repair should be done by a qualified service technician

Accepts interchangeable decorative panels and Firescreen companions. DF-6-FS Chateau Deluxe Front In black, bronze or pewter. DF-6-CHAD Essence Doors Available in all five finishes. Accepts interchangeable decorative panels. DF-6-ESSENCE DF-6000 In black, bronze or pewter. DF-6000 Finishes Five rich finishes. High on style, long on durability. Available on select fronts. Firescreen Companions for use with Firescreen front. Adds a distinctive touch of corner detail. Available in black, b

• Keep remote controls out of reach of children. • Never leave children alone near a hot fireplace, whether operating or cooling down. • Teach children to NEVER touch the fireplace. • Consider not using the fireplace when children will be present. Contact your dealer for more information, or visit: hpba.org/staysafe. To prevent unintended operation when not using your fireplace for an extended period of time (summer months, vacation, trips, etc): • Remove batteries from remote controls. • Turn o