Оценок - , средний балл:
(
)
)
Производитель: Raypak
Размер: 2.43 mb
Название файла: 00b3ee5f-d57e-4ab3-ae81-fd71aceac305.pdf
Язык инструкции:
Документ загружается, подождите пожалуйста
 |
Документ загружается, подождите пожалуйста
Фрагмент инструкции
To do so may result in an explosion or fire. WARNING: Improper installation, adjustment, alteration, service or maintenance can cause property damage, personal injury or loss of life. Refer to the user.s information manual provided with this boiler. Installation and service must be performed by a qualified installer, service agency or the gas supplier. FOR YOUR SAFETY WHATTO DO IF YOU SMELL GAS: · Do not try to light any appliance. · Do not touch any electrical switch; do not use any phone in your building. · Immediately call your gas supplier from a neighbor.s phone. Follow the gas supplier.s instructions. · If you cannot reach your gas supplier, call the fire department. This manual should be maintained in legible condition and kept adjacent to the boiler or kept in a safe place for future reference. P/N 240757 TABLE OF CONTENTS PAGE NO. 4 SECTION A: BEFORE INSTALLING THE BOILER 8 SECTION B: BOILER INSTALLATION 11 SECTION C: COMBUSTION AND VENTILATION AIR 13 SECTION D: WATER PIPING - GENERAL 14 SECTION E: HYDRONIC HEATING PIPING 16 SECTION F: DOMESTIC HOT WATER PIPING 17 SECTION G: POOL HEATING 19 SECTION H: GAS SUPPLY CONNECTIONS 21 SECTION I: ELECTRICAL POWER CONNECTIONS 24 SECTION J: VENTING CONNECTIONS 28 J-1: Natural Draft Vertical Venting 31 J-2: Horizontal Thru-Wall Venting 34 J-3: Horizontal Thru-Wall Direct Venting 36 J-4: Vertical Direct Venting/Combustion Air 38 J-5: Outdoor Installation 43 SECTION K: CONTROLS 49 WIRING DIAGRAMS 53 SECTION L: GENERAL SAFETY PRECAUTIONS 54 SECTION M: PRE-START-UP 55 SECTION N: HI-DELTA INITIAL START-UP 59 SECTION O: POST START-UP CHECK 60 SECTION P: OPERATION 61 SECTION Q: MAINTENANCE 63 APPENDIX A: COMBUSTION AIR CONTAMINATION 64 WARRANTY DANGER: WARNING: DANGER: WARNING: WARNING: WARNING: WARNING: CAUTION: CAUTION: CAUTION: Make sure the gas on which the boiler will operate is the same type as that specified on the boiler model and rating plate. Should overheating occur or the gas supply valve fail to shut, do not turn off or disconnect the electrical supply to the boiler. Instead, shut off the gas supply at a location external to the appliance. Do not use this boiler if any part has been under water. Immediately call a qualified service technician to inspect the boiler and to replace any part of the control system and any gas control which has been under water. To minimize the possibility of improper operation, serious personal injury, fire, or damage to the boiler, never violate the following safety rules: 1. Always keep the area around the boiler free of combustible materials, gasoline, and other flammable liquids and vapors. 2. Boiler should never be covered or have any blockage to the flow of fresh air to the boiler. Risk of electrical shock. More than one (1) disconnect switch may be required to de- energize the equipment before servicing. Operation of this boiler on low temperature systems requires special piping to insure correct operation. If this boiler is to be installed above radiation level, it must be provided with a low water cutoff device at the time of boiler installation. This boiler requires forced water circulation when the burner is operating. See minimum and maximum flow rates. Severe damage will occur if the boiler is operated without proper water flow circulation. CALIFORNIA PROPOSITION 65 WARNING: This product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. 3 Pay attention to these terms: DANGER: WARNING: CAUTION: NOTICE: indicates the presence of immediate hazards which will cause severe personal injury, death or substantial property damage if ignored. indicates the presence of hazards or unsafe practices which could cause severe personal injury, death or substantial property damage if ignored. indicates the presence of hazards or unsafe practices which could cause minor personal injury or product or property damage if ignored. indicates special instructions on installation, operation, or maintenance which are important but not related to personal injury hazards. SECTION A: BEFORE INSTALLING THE BOILER Raypak strongly recommends that this manual be reviewed thoroughly before installing your Raypak boiler. Please review the General Safety Precautions on Section L before installing the boiler. Factory warranty does not apply to boilers that have been improperly installed or operated. Installation and service must be performed by a qualified installer, service agency or gas supplier. If, after reviewing this manual, you still have questions which this manual does not answer, please contact the factory or your local Raypak representative. Thank you for purchasing a Raypak product. We hope you will be satisfied with the high quality and durability of our equipment. PRODUCT RECEIPT On receipt of your product it is suggested that you visually check for external damage to the shipping crate. If the crate is damaged, make a note to that effect on the Bill of Lading when signing for...