Оценок - 2, средний балл: 3
(
)
)
|
Фрагмент инструкции
. . . . . . . . . . . . . .1 B.SPECIAL ATTENTION BOXES . . . . . . . . . . . .1 1. PREINSTALLATION 2 A. ACCESSIBILITY CLEARANCES . . . . . . . . . . .2 B. CLEARANCE FROM COMBUSTIBLE CONSTRUCTION . . . . . . . . . . . . . . . . . . . . . .3 C. COMBUSTION AND VENTILATION AIR . . . .3 D.CHIMNEYORVENT . . . . . . . . . . . . . . . . . . . .3 E.BOILERSETTING . . . . . . . . . . . . . . . . . . . . . .4 F. INSTALLATION SURVEY . . . . . . . . . . . . . . . .5 G. PLANNING THE LAYOUT . . . . . . . . . . . . . . . .5 H.VERIFYCOMPONENTS . . . . . . . . . . . . . . . . .5 2. PLACE THE BOILER 10 A.PACKAGED BOILER . . . . . . . . . . . . . . . . . . .10 B.ASSEMBLED BLOCK BOILER . . . . . . . . . . .10 C. KNOCKDOWN BOILER – PLACING THE SECTIONS . . . . . . . . . . . . . . . . . . . . . .10 D.INSTALL COILS OR PLATES . . . . . . . . . . . .17 E. HYDROSTATIC TEST THE BOILER . . . . . . .17 F. APPLY CLEANOUT COVER PLATES . . . . . .18 G.INSTALL FLUE COLLAR . . . . . . . . . . . . . . . .18 H.INSTALL FLUE BAFFLES . . . . . . . . . . . . . . .19 I. INSTALL CHAMBER LINER . . . . . . . . . . . . .19 3. PIPE THE BOILER 20 A.PREPARATION . . . . . . . . . . . . . . . . . . . . . . .20 B.SUPPLY AND RETURN PIPING . . . . . . . . . .20 C. LOW SYSTEM TEMPERATURE . . . . . . . . . .20 D.CHILLED WATER SYSTEMS . . . . . . . . . . . .23 E.HIGH FLOW RATE PIPING . . . . . . . . . . . . . .23 F. MULTIPLE BOILER INSTALLATIONS . . . . . .23 4. ASSEMBLE THE JACKET 27 A.PREPARE THE PARTS . . . . . . . . . . . . . . . . .27 B. APPLY JACKET SIDES AND CORNERS . . .27 C. APPLY JACKET FRONT PANELS . . . . . . . . .27 D.APPLY JACKET REAR PANEL . . . . . . . . . . .27 E.APPLY JACKET TOP PANELS . . . . . . . . . . .27 F. APPLY PLATES AND LABELS . . . . . . . . . . .27 5. VENTING 6. INSTALL THE BURNER A.BURNER APPLICATION . . . . . . . . . . . . . . . .29 B. INSTALL BURNER MOUNTING PLATE . . . .29 C. MOUNT THE BURNER . . . . . . . . . . . . . . . . .29 7. CONNECT FUEL PIPING 31 A.GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . .31 B. INSTALL FUEL OIL PIPING . . . . . . . . . . . . .31 C.INSTALL GAS SUPPLY PIPING . . . . . . . . . .31 D.TEST GAS SUPPLY PIPING . . . . . . . . . . . . .31 8. INSTALL CONTROLS AND TRIM 33 A. INSTALL SAFETY RELIEF VALVE . . . . . . . .33 B. INSTALL DRAIN VALVE . . . . . . . . . . . . . . . .33 C. INSTALL LOW WATER COUTOUT(S) . . . . .33 D.INSTALL CONTROLS & TRIM . . . . . . . . . . .33 E. PIPE TANKLESS HEATERS IF USED . . . . . .34 F. CONNECT SUPPLY WIRING . . . . . . . . . . . .34 G.INSTALL CONTROL WIRING . . . . . . . . . . . .34 9. STARTING THE BOILER 37 A.CHECK THE PIPING . . . . . . . . . . . . . . . . . . .37 B. FILL THE BOILER . . . . . . . . . . . . . . . . . . . . .37 C.RUN BURNER CHECK-OUT . . . . . . . . . . . . .37 D.CHECK BOILER CONTROLS . . . . . . . . . . . .38 10. MAINTENANCE 39 A. PLACING BOILER IN OPERATION . . . . . . . .40 B. TOSHUT DOWN THE BOILER . . . . . . . . . .40 C. MAINTENANCE – ANNUAL . . . . . . . . . . . . .40 D.MONTHLY MAINTENANCE . . . . . . . . . . . . .41 E. DAILY MAINTENANCE . . . . . . . . . . . . . . . . .41 11. BOILER RATINGS & DIMENSIONS 12. REPAIR PARTS A SERIES LC BOILER ASSEMBLY . . . . . . . . .45 B. SERIES LCE BOILER ASSEMBLY . . . . . . . .48 A. INSTRUCTION MANUALS The Series LC/LCE Installation, Operation & Maintenance Manual is divided into four basic sections: 1. Preinstallation (Section 1) 2. Installation (Sections 2 through 8) 3. Start-Up (Section 9) 4. Maintenance (Section 10) B. SPECIAL ATTENTION BOXES Throughout this manual you will see special attention boxes intended to supplement the instructions and make special notice of potential hazards. These categories mean, in the judgment of PB Heat, LLC: Indicates special attention is needed, but not directly related to potential personal injury or property damage. NOTICEIndicates a condition or hazard which will or can cause minor personal injury or property damage. CAUTIONDANGERIndicates a condition or hazard which will cause severe personal injury, death or major property damage. USING THIS MANUAL USING THIS MANUAL Indicates a condition or hazard which may cause severe personal injury, death or major property damage. WARNINGIndicates a condition or hazard which will or can cause minor personal injury or property damage. CAUTIONDANGERIndicates a condition or hazard which will cause severe personal injury, death or major property damage. USING THIS MANUAL USING THIS MANUAL Indicates a condition or hazard which may cause severe personal injury, death or major property damage. WARNING PREINSTALLATION PREINSTALLATION 1. PREINSTALLATION NOTICE The equipment must be installed in accordance with installation requirements of the authority having jurisdiction or, in the absence of such requirements, to the current edition of the National Fuel Gas Code, ANSI Z223.1/NFPA 54. Where required by the authority having jurisdiction, the installation must conform to American Society of Mechanical Engineers Safety Code for Controls and...