Оценок - 3, средний балл: 4.3 ( )

Производитель: APW Wyott Размер: 529.37 kb Название файла: Язык инструкции:

If you can pull the capillary tube and the bulb moves it is not held tight enough against the griddle plate. This will cause variations in the temperature of the griddle surface. If both of these items have been checked and you still have a differential over 75.F then the thermostat is bad replace it. Determine the average temperature Note the temperature for each section of the griddle as the burners ignite. Note the temperature for each section of the griddle as the flame extinguishes. The flame extinguish temperature plus the flame ignition temperature divided by two equals the average temperature. EXAMPLE: Flame extinguished 367.F Flame ignition 341.F 708. / 2 Average temperature = 354.F If the average temperature is within 15.F of the dial marking you probably leave the calibration where it is. If the average temperature is outside of 15.F of the dial setting you will want to calibrate the thermostat. To calibrate a thermostat first remove the knob by pulling it straight off the shaft. Next take a small flat head screw drive and turn the screw inside the shaft, clockwise to decrease, counterclockwise to increase. . turn clockwise will decrease the temperature approximately 24.F. . turn counterclockwise will increase the temperature approximately 24.F. Adjust and re-measure the average temperature until you get the temperature to your desired point. NOTE: avoid making more than . turn at a time. Calibration is not linear and you can get the thermostat significantly out of calibration to a point where it is difficult to reset. If after adjusting the thermostat three times and getting no change in calibration the thermostat is bad. Then replace the thermostat. 9 TROUBLESHOOTING GUIDE PROBLEM POSSIBLE CAUSE Heat does not come on when thermostat is turned on. Thermostat is bad. Pilot burner not lit. Gas valve is bad. Pilot burner will not light. Obstructed pilot orifice. Pilot gas turned off at automatic pilot. Automatic pilot valve is bad. Pilot burner will not stay lit. Thermocouple is bad. Thermocouple is not hot enough. Obstructed or wrong size pilot orifice. Gas supply is not purged of air. Air is blowing pilot light out. Automatic pilot valve is bad. Fat appears to smoke excessively. Heat is set too high. Moisture in the food may be turning into steam. Food sticks to griddle. Heat is set too high. Griddle surface needs cleaning and/or seasoning. Surface under food may not have been covered with enough cooking oil. Food burned around edges or contains dark specks. Heat is set too high. Griddle surface needs cleaning and/or seasoning. Surface under food may not have been covered with enough cooking oil. Food is undercooked inside. Heat is set too high. Food may not have been cooked for long enough time. Food tastes greasy or has objectionable off-flavor. Food itself may have off flavor. Food may have been stored improperly before cooking. Too much griddle fat used. Heat is set too low. Noticeable build-up of gum on griddle. Heat is set too high Griddle surface needs cleaning and/or seasoning. Too much griddle fat used. 10 NOTES 12 PARTS LISTS & EXPLODED VIEWS GGM GRIDDLES (EXPLODED VIEW) 40 22 16 17 18 5 7 8 11 21 41 32 42 23 33 43 24 44 15 25 35 45 26 36 37 48 49 20 30 50 39 2 4 34 38 3 19 29 28 27 56 12 9 10 14 46 47 1 6 31 13 GGM - PARTS LIST ITEM P/N DESCRIPTION QTY. QTY.ITEM DESCRIPTIONP/N 1 218215-20 Weldment, Griddle GGM-18 1 24 24251-00 Pan, Grease 18" Varies 218216-20 Weldment, Griddle GGM-24 1 24250-00 Pan, Grease 24" Varies 218217-20 Weldment, Griddle GGM-36 1 25 8861000 Label, Spec 1 218218-20 Weldment, Griddle GGM-48 1 26 218215-12 Panel, Back GGM-18 1 2 218215-11 Body, 18" Firebox GGM 1 218216-12 Panel, Back GGM-24 1 218216-11 Body, 24" Firebox GGM 1 218217-12 Panel, Back GGM-36 1 218217-11 Body, 36" Firebox GGM 1 218218-12 Panel, Back GGM-48 1 218218-11 Body, 48" Firebox GGM 1 27 8196601 Nut, U-Type 4 3 21820728 Tube, Pilot Supply GGM-18 1 28 21820719 Panel, Control 1 21820727 Tube, Pilot Supply GGM-24/36/48 Varies 21820819 Panel, Control 1 4 2066154 Pilot, Top 1 21820919 Panel, Control 1 2092800 Pilot, Broiler Varies 21821019 Panel, Control 1 5 218207-23 Support, Leg-18 2 29 30047501 Guide, Grease Slide Varies 218208-23 Support, Leg-24 2 30 8170700 Screw, 10-32x1/2, Type AB Varies 218209-23 Support, Leg-36 2 31 8837120 Label, Orifice Size 1 218210-23 Support, Leg-48 2 32 218207-24 Baffle, Front Panel 18" 1 6 218207-16 Side, Grease Chute Varies 218208-24 Baffle, Front Panel 24" 1 7 2092517 Plug, 1/8 NPTM Varies 218209-24 Baffle, Front Panel 36" 1 8 218220-50 Side Panel, RH 1 218210-24 Baffle, Front Panel 48" 1 9 81546-00 #8 X 3/8 4 33 81973-00 T/S #10 X . TPB Tr Hd 4 10 218207-17 Support, Burner-18 2 34 218208-26 Cap, End Control Panel R.H. 1 218208-17 Support, Burner-24 2 35 218208-27 Cap, End Control Panel L.H. 1 218209-17 Support, Burner-36 2 36 8353000 Pop Rivet 2 218210-17 Support, Burner-48 2 37 8632000 Leg, 4" Adj., 2000 Lb Cap. 4 11 2066844 Orfice, #44 Varies 38 8705800 Knob, Med....

Скачать инструкцию

Чтобы скачать, введите 2 цифры: