Оценок - 4, средний балл: 4
(
)
)
|
Фрагмент инструкции
NOTE: If the vehicle is constantly subjected to heavy use or severe operating conditions, the preventive maintenance procedures should be performed more often than recommended in the Periodic Service and Lubrication Schedule. Both the Periodic Service Schedule and the Periodic Lubrication Schedule must be followed to keep vehicle in optimum operating condition. PERIODIC SERVICE SCHEDULE REGULAR INTERVAL SERVICE Daily service by owneror trained technician Engine Check engine oil level; add if necessary. See Engine Oil Level Check onpage 35. Diesel vehicles: Check engine coolant; add if necessary. See Engine CoolantLevel Check on page 42. Fuel filters Diesel vehicles: Drain water from fuel filter. See Draining Water from FuelFilter on page 45. Brakes Check brake fluid; add if necessary. Check brake pedal for proper operation. See Performance Inspection on page 18. Periodic Service Schedule continued on next page.... 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual Page 29 Periodic Service Schedule PERIODIC SERVICE SCHEDULE REGULAR INTERVAL SERVICE Monthly service by owneror trained technician Engine Check engine circulating air passage; visually inspect unshrouded area around engine exhaust for grass and debris and clean if necessary. Diesel vehicles: Check for grass and debris around the radiator. Tires Check air pressure and adjust if necessary. See Vehicle Specificationson page 51. Transmission and differentials Check lubricant levels. Add if necessary. See Lubrication Level Check for Front Differential, Transmission, and Rear Differential on page 40. General vehicle Wash engine compartment and underside of vehicle. Do not wash engine when hot. First adjustment after 20 hours, additional every 100 hours of operation Engine (Honda) Adjust valve clearance. See Honda GX620 Service Manual (CCI P/N 102615401). Semiannual service by trainedtechnician only(or every 50 hours of operation, whichever comes first) Battery Clean terminals and wash dirt from casing; check electrolyte level. Add distilled water if necessary. See page 47. Front wheel alignment and toe-in Check and adjust if necessary. See Section 7 – Steering and FrontSuspension in the appropriate maintenance and service manual. Electrical wiring and connections Check for tightness and damage. Brake system Inspect master cylinder, brake lines, and hoses for damage or leakage. Check park brake cables for damage; replace if necessary. Check brake pads and discs; replace if necessary. For brake wear-in procedure, see Hydraulic Brakes in the Pre-Operation and Daily SafetyChecklist on page 17. See also Section6 – Brake System in the appropriate maintenance and service manual. Periodic Service Schedule continued on next page.... Page 30 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual Periodic Service Schedule PERIODIC SERVICE SCHEDULE REGULAR INTERVAL SERVICE Annual service bytrained technician only(or every 100 hours of operation, whichever comes first) Engine Check for leaks around gaskets, fill plugs, etc. Kawasaki gasoline engines: Adjust valve clearance. See Kawasaki FH680D Service Manual. Gasoline vehicles: Inspect, clean, and gap spark plug; replace if necessary. See authorized dealer or trained technician for service. Diesel vehicles: Check the v-belt for proper tension or damage. Adjust or replace if necessary. Diesel vehicles: Change engine coolant. See Section 15 – Radiator and CoolingSystem in the maintenance and service manual. Radiator Diesel vehicles: Check clights for tightness; check hoses for cracks. Replace if necessary. Engine air intake system Replace air filter element. See Air Intake System on page 42. Check clights for tightness; check hose for cracks. General vehicle Check for loose hardware and tighten if necessary. Fuel filters Replace. Dispose of used filters properly. y WARNING • If any problems are found during scheduled inspection or service, do not operate vehicle until repairs are made. Failure to make necessary repairs could result in fire, property damage, severe personal injury, or death. 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual Page 31 Periodic Lubrication Schedule PERIODIC LUBRICATION SCHEDULE PERIODIC LUBRICATION SCHEDULE REGULAR INTERVAL SERVICE LUBRICATION POINTS RECOMMENDED LUBRICANT Gasoline vehicle: Honda engine-First change20 hours Kawasaki engine-Firstchange 10 hoursDiesel vehicle: First change 50 hoursAdditional change for all engines every 100 hours ofoperation or annually, whichever comes first. Change engine oil and oil filter 1 Gasoline (Honda engine)vehicles: 1 qt. and 25 oz (1.7 L) with filter Gasoline (Kawasaki engine) vehicles: 1 qt. and 19 oz (1.5L) with filter Diesel vehicles: 3 qt. (2.8 L) with filter See Oil Viscosity on page 39. Monthly by owner ortrained technician Driveshaft 2 Chassis Lube (EP NLGI Grade 2) Semiannually by owneror trained technician (orevery 50 hours ofoperation, whichever comes first) Check/add brake fluid 3 Use only DOT 5 (silicone) brake fluid Rea...
Эта инструкция также подходит к моделям:Оборудование к ТС - HUV 4421-D / DXP (3.34 mb)